Household Move
Thai Rice Export
About Thai Rice
 |
|
About Thai Rice Mill
|
The practical before harvest.
- Make conversion from rice
paddy-term yield. If ears pop from the ground
leaves 80% of the conversion flag is set on
blow.
- 21 days after bloom. Drainage from paddy
conversion.
- 28-30 days after bloom. Set a date harvest.
|
|
|
|
Drainage from the conversion. 7-10 days
prior to harvest rice.
|
Appropriate harvest time.
|
|
Harvest time.
- Harvesting too early.
1. Grain lightweight. Starch accumulation is not
full.
2. Color, low seed quality to be less green
pepper.
- Harvesting too late.
1. Fall in rice paddy. Because rice crispy dry.
2. To destroy the insects, birds and mice.
3. The quality of color is not good. Because the
seeds division.
4. Seed germination in paddy.
|
|
|
|
Seed division.
|
Seed germination.
|
- Appropriate harvest period (28-30 days
after bloom) rice has a good quality color.
How to harvest.
- The workers who harvest: slow and low-wage
workers.
- Harvested by machine on Foot: fast, but
Rice has high humidity.
 |
Using solar. A
source of heat. The movement of air helps to
take moisture from the seeds. Cause of grain
moisture content decreased. How low is not
difficult, but there are disadvantages. Labor
and space to dry. And can not control the
quality of rice.
: In the dry rice paddy. Cause
the loss of both weight and quality of rice.
Weight of rice was reduced because the birds
destroy the mice fall as dry as the sun and move
the loss of quality. Because of dry leaves in
rice paddy. Rice was in the daytime high
temperature from the sun. Moisture content of
grain decreased while the rice dry nights. Lower
temperature. Higher relative humidity of air.
Rice has absorbed moisture back into again.
Changes in grain moisture content. Alternately
dry and moist. Resulting in pain when the rice
seeds to massage or color. There is a fracture.
Quality of color reduction. Also affected by
environment, such as mush dew at night. During
rainy or dry.
|
|
|
|
The dry rice.
|
Dry rice in paddy.
|
|
|
|
Drying time in minutes Rice affect color
quality.
|
: The dry ground now about the
car massage. Rice farmers sell fresh (damp) the
dealer immediately. Therefore, the burden in
reducing humidity, so merchants were farmers or
mill, but some groups continue to reduce the
moisture dried rice itself. Or stored for a
seed. The dry rice on the ground following a
rule.
1. Courtyard dry cleaning.
Materials should be clean and dry seeds support.
Such as canvas or a building with bamboo mats,
etc. should not be dry on the floor or concrete
road directly. Because the seeds may have been
too hot.
2. Thickness of the dry stack thickness should
approximately 5 to 10 cm thick and too dry to
allow good ventilation is not some dry rice dry
and too slow. Rice made a high temperature
affect the germination of rice. During the dry
stack should keep back every 2 hours or 4 times
per day to reduce moisture quickly and
consistently.
3. Should be covered with material stack to
prevent dew or rain.
4. Do not dry rice for too long. Length of dry
rice. Subject to moisture from. Thickness of
rice when dried. And often in the back. As well
as humidity levels generally required if
moisture is reduced to approximately 12 to 14%
off so dry.
The dry ground.
-. The use of a roast. This is
meritorious. Can perform in all weather
conditions. Although rain is falling or has less
sunlight. Using less space. Control to reduce
moisture. To the desired level. Control can
prevent damage to the quality of rice, but there
are disadvantages of high cost. And practical
difficulties.
|
|
Quality rice.
1. The quality of color.
Color quality evaluation of rice from the
full amount of rice from rice and beans.
Rice quality and good color. When processed,
and then polish. Rice is full of rice seed
and early high. A little less volume, so the
evaluation of rice milling quality of rice
has become associated with the rice. Or
rice. Those from rice are.
1.) Approximately 20-24% of paddy
husk. A mix of straw and husk seed sepal
seed rack.
2). Bran approximately 8-10% of paddy. A
mix of synovial results. Synovial seeds.
Synovial Cup Pa meat and grain surface
of rice.
3.) Approximately 68-70% of paddy rice.
News from the polished white will be
isolated. A full-grain rice from rice
and broken rice in quantities much
depends on the quality paddy before
color. If paddy quality. Rice is full of
high rice grain and rice from less tax.
2. The quality of trading.
Evaluation of rice quality in the trade.
Which include rice pricing.
1). Humidity play an important role
in determining the price of rice. Rice
harvest in the appropriate period. And
reduce moisture to properly remaining
13-15% higher than the price of rice has
high humidity. Because rice is dry at
the right humidity. Can make a color. Be
reduced without additional moisture. If
purchased rice with high moisture
content. Must be free to reduce
humidity. Rice and weight loss after
reducing humidity, so rice is excessive
moisture has been undercut.
2.) Physical characteristics of rice.
The mine Etaa. And polish to evaluate
the color brown rice, eggs and bodies of
the seed crystal clear. And other
contaminants, such as rice, red rice,
yellow rice or rice, other types of
waste a year so that these
characteristics in different quantities.
Determines the price of rice.
3.) Quality evaluation of color to
become from a rice paddy. Total volume
of rice. Full-grain rice from rice
broken rice and broken-milled rice, the
effect sizes from the friction of rice
are taken. The mill will be up to
evaluation by the mill converted into
fact. General mill will set a minimum
threshold of results from the friction
of rice purchased. If rice farmers to
sell the effect of friction is lower
than the criteria will be undercut.
4.) Types of rice rice quality by
market demand and the popularity of
consumers. Such as jasmine rice. Often
have better prices than white rice.
|
|
|
|
|
|
Reduce
humidity.
